塑性混凝土的长期渗流溶蚀稳定性试验
为了评定塑性混凝土的长期渗流稳定性和使用年限，结合当地原材料的情况，采用膨润土、黏土、水泥、骨料、水和减水剂等来制备塑性混凝土，试验测定了完整或含孔洞塑性混凝土的长期渗流稳定性和使用年限。经过多次试配试验，选定配合比并制作试件，该试件在标准养护28 d后，其抗压强度为1.25 MPa。分别制备、使用2组共12个试件进行溶蚀试验或冲淋试验。溶蚀试验表明，在溶蚀试验的测试初期，渗透系数是不断变化的，尤其在试验前30～40 d是比较明显的，但均在10^-7 cm/s数量级。随溶蚀时间的延长，混凝土试件中被溶蚀CaO的数量呈线性递减关系，直至降低到自来水所含CaO的浓度范围，而渗透系数在150～180...
Saved in:
| Published in | 农业工程学报 Vol. 30; no. 22; pp. 112 - 119 |
|---|---|
| Main Author | |
| Format | Journal Article |
| Language | Chinese |
| Published |
新疆农业大学水利与土木工程学院,乌鲁木齐,830052%新疆农业大学草业与环境科学学院,乌鲁木齐,830052
2014
|
| Subjects | |
| Online Access | Get full text |
| ISSN | 1002-6819 |
| DOI | 10.3969/j.issn.1002-6819.2014.22.014 |
Cover
| Abstract | 为了评定塑性混凝土的长期渗流稳定性和使用年限，结合当地原材料的情况，采用膨润土、黏土、水泥、骨料、水和减水剂等来制备塑性混凝土，试验测定了完整或含孔洞塑性混凝土的长期渗流稳定性和使用年限。经过多次试配试验，选定配合比并制作试件，该试件在标准养护28 d后，其抗压强度为1.25 MPa。分别制备、使用2组共12个试件进行溶蚀试验或冲淋试验。溶蚀试验表明，在溶蚀试验的测试初期，渗透系数是不断变化的，尤其在试验前30～40 d是比较明显的，但均在10^-7 cm/s数量级。随溶蚀时间的延长，混凝土试件中被溶蚀CaO的数量呈线性递减关系，直至降低到自来水所含CaO的浓度范围，而渗透系数在150～180 d时增至3.0×10^-7 cm/s，且逐渐趋于稳定。经180 d的渗流溶蚀作用后，塑性混凝土会产生剪损裂缝和拉断裂缝，甚至有较大的塑性变形，导致试件顶面平均上升位移值高达38.5 mm。通过溶蚀试验计算该塑性混凝土的渗透系数和CaO含量，然后计算塑性混凝土防渗墙使用年限为37.1～60.7 a。冲淋试验表明：水流会在含孔洞的混凝土中产生集中冲刷且局部混凝土中的 CaO 被溶蚀并随水流携带走，经过测定分析，水流从孔中冲蚀出的白色沉淀物为碳酸钙，另有少量的Na＋、微量黏土和膨润土颗粒，从而降低了混凝土的质量。在恒压水流作用下，水流对已含孔洞混凝土的冲刷较弱，混凝土中被溶蚀并携带走的CaO较少，即使冲淋197 d后，其前后的质量的损失较小，相对损失不超过1%，但其强度损失较大，高达25.4%。综合研究表明：采用黏土和膨润土制备的塑性混凝土符合土石坝防渗墙防渗的特点，具有水泥用量小、强度低、高抗渗性和使用年限长的特点。 |
|---|---|
| AbstractList | TU528.01; 为了评定塑性混凝土的长期渗流稳定性和使用年限，结合当地原材料的情况，采用膨润土、黏土、水泥、骨料、水和减水剂等来制备塑性混凝土，试验测定了完整或含孔洞塑性混凝土的长期渗流稳定性和使用年限。经过多次试配试验，选定配合比并制作试件，该试件在标准养护28 d后，其抗压强度为1.25 MPa。分别制备、使用2组共12个试件进行溶蚀试验或冲淋试验。溶蚀试验表明，在溶蚀试验的测试初期，渗透系数是不断变化的，尤其在试验前30～40 d是比较明显的，但均在10-7 cm/s数量级。随溶蚀时间的延长，混凝土试件中被溶蚀CaO的数量呈线性递减关系，直至降低到自来水所含CaO的浓度范围，而渗透系数在150～180 d时增至3.0×10-7 cm/s，且逐渐趋于稳定。经180 d的渗流溶蚀作用后，塑性混凝土会产生剪损裂缝和拉断裂缝，甚至有较大的塑性变形，导致试件顶面平均上升位移值高达38.5 mm。通过溶蚀试验计算该塑性混凝土的渗透系数和CaO含量，然后计算塑性混凝土防渗墙使用年限为37.1～60.7 a。冲淋试验表明：水流会在含孔洞的混凝土中产生集中冲刷且局部混凝土中的 CaO 被溶蚀并随水流携带走，经过测定分析，水流从孔中冲蚀出的白色沉淀物为碳酸钙，另有少量的Na+、微量黏土和膨润土颗粒，从而降低了混凝土的质量。在恒压水流作用下，水流对已含孔洞混凝土的冲刷较弱，混凝土中被溶蚀并携带走的CaO较少，即使冲淋197 d后，其前后的质量的损失较小，相对损失不超过1%，但其强度损失较大，高达25.4%。综合研究表明：采用黏土和膨润土制备的塑性混凝土符合土石坝防渗墙防渗的特点，具有水泥用量小、强度低、高抗渗性和使用年限长的特点。 为了评定塑性混凝土的长期渗流稳定性和使用年限，结合当地原材料的情况，采用膨润土、黏土、水泥、骨料、水和减水剂等来制备塑性混凝土，试验测定了完整或含孔洞塑性混凝土的长期渗流稳定性和使用年限。经过多次试配试验，选定配合比并制作试件，该试件在标准养护28 d后，其抗压强度为1.25 MPa。分别制备、使用2组共12个试件进行溶蚀试验或冲淋试验。溶蚀试验表明，在溶蚀试验的测试初期，渗透系数是不断变化的，尤其在试验前30～40 d是比较明显的，但均在10^-7 cm/s数量级。随溶蚀时间的延长，混凝土试件中被溶蚀CaO的数量呈线性递减关系，直至降低到自来水所含CaO的浓度范围，而渗透系数在150～180 d时增至3.0×10^-7 cm/s，且逐渐趋于稳定。经180 d的渗流溶蚀作用后，塑性混凝土会产生剪损裂缝和拉断裂缝，甚至有较大的塑性变形，导致试件顶面平均上升位移值高达38.5 mm。通过溶蚀试验计算该塑性混凝土的渗透系数和CaO含量，然后计算塑性混凝土防渗墙使用年限为37.1～60.7 a。冲淋试验表明：水流会在含孔洞的混凝土中产生集中冲刷且局部混凝土中的 CaO 被溶蚀并随水流携带走，经过测定分析，水流从孔中冲蚀出的白色沉淀物为碳酸钙，另有少量的Na＋、微量黏土和膨润土颗粒，从而降低了混凝土的质量。在恒压水流作用下，水流对已含孔洞混凝土的冲刷较弱，混凝土中被溶蚀并携带走的CaO较少，即使冲淋197 d后，其前后的质量的损失较小，相对损失不超过1%，但其强度损失较大，高达25.4%。综合研究表明：采用黏土和膨润土制备的塑性混凝土符合土石坝防渗墙防渗的特点，具有水泥用量小、强度低、高抗渗性和使用年限长的特点。 |
| Abstract_FL | In order to evaluate long-term seepage stability and service life of plastic concrete that are made of bentonite, clay, cement, soil aggregate, water, superplasticizer, etc., we studied incomplete or contain holes of plastic concrete’s long-term seepage stability and service life. Specimens of plastic concrete were molded after many times of tests, and their compressive strength of 28 days was 1.25 MPa, and meet requirements impermeability grade was S1 which was test code for hydraulic concrete because water pressure measured was 0.2 MPa by step by step method. The preparation of plastic concrete permeability test required to a round-shaped specimen (top diameter is 175 mm, basal diameter is 185 mm, height is 150 mm). Type I was complete specimens of concrete impermeability;and Type II specimens were high in the direction parallel to the reserved five through holes with a diameter of 3.5 mm, plum-shaped layout was on the plane. It was found after long-term corrosion test plastic concrete can produce shear cracks and tensile cracks and even had lager plastic deformation after long-term seepage dissolution by pure water, which led to damage of the plastic concrete. This resulted in an increase of maximum displacement values of top surface of the specimen by 38.5 mm on average. The permeability coefficient was changed in the early (30 to 40 days) penetration test, but they were in 10-7 cm/s orders of magnitude. The permeability coefficient was increased to 3.0×10-7 cm/s and then tended to be stable during 150-180 days. Ca2+were dissolved from the concrete and leached out after long-term seepage dissolution, the amount of Ca2+removed from concrete specimens were linearly decreasing as dissolution time (<150 days). The concentration of Ca2+ in the specimen water seepage fell below 110 mg/L after 180 days of dissolution. Through dissolution experiment, calculating plastic concrete’s coefficient of permeability and content of CaO were done based on the formula of diaphragm wall’s durable years, the calculated service life was 37.1-60.7 years. Drench experiment showed that flows may create preferential erosion in holes in concrete, and Ca(OH)2 in concrete were dissolved and carried away by the flow which led to decrease in weight of plastic concrete. The flow of constant pressure through holes of concrete was relatively weak, and few Ca in concrete were dissolved and carried away. Even after drench 197 d, there was less quality loss compare with the original, the relative loss was not more than 1%. However the concrete strength loss was larger (up to 25.4%). The white precipitates in the hole were CaCO3, and some Na+, trace clay and bentonite particles after laboratory analysis. The studies showed that the features of plastic concrete made of clay and bentonite had a low-intensity, high impermeability and long service life which met the requirement of impervious wall of earth-rock fill dam. Thus, it can be used for embankment dam for seepage prevention. |
| Author | 吴福飞 侍克斌 董双快 慈军 努尔开力·依孜特罗甫 |
| AuthorAffiliation | 新疆农业大学水利与土木工程学院,乌鲁木齐830052 新疆农业大学草业与环境科学学院,乌鲁木齐830052 |
| AuthorAffiliation_xml | – name: 新疆农业大学水利与土木工程学院,乌鲁木齐,830052%新疆农业大学草业与环境科学学院,乌鲁木齐,830052 |
| Author_FL | NuerkailiYiziteluopu Wu Fufei Shi Kebin Dong Shuangkuai Ci Jun |
| Author_FL_xml | – sequence: 1 fullname: Wu Fufei – sequence: 2 fullname: Shi Kebin – sequence: 3 fullname: Dong Shuangkuai – sequence: 4 fullname: Ci Jun – sequence: 5 fullname: NuerkailiYiziteluopu |
| Author_xml | – sequence: 1 fullname: 吴福飞 侍克斌 董双快 慈军 努尔开力·依孜特罗甫 |
| BookMark | eNo9jz9Lw0AAxW-oYK39EiI4Jd7_5EYp_oOCg-7hcs3FFL1ogmi3CoJLF4cihEpxUhx0EK24-GmStt_ChIrLe_D48R5vBdRMbAIA1hG0ieBis2tHaWpsBCG2uIuEjSGiNsZ2aTVQ_8-XQTNNIx8yRBwIKaoDkj_eFf2nYjLJbx_y0Xia3cyHP8VoXHzdFx_XxffnLOtPn9_z16zEZm_D-ctgFSxpeZIGzT9vgMOd7aPWntU-2N1vbbUtxQS1AsZ94ksoHMwIJq5iWLMOZlwL7XaY1ggrFmgpqkwJn0AmXaZcSrEkgUsaYGPReimNlib0uvFFYso9z_RCdeVXF3ElJbm2INVxbMLzqGTPkuhUJj2Pc0Ic6lBMfgGurme0 |
| ClassificationCodes | TU528.01 |
| ContentType | Journal Article |
| Copyright | Copyright © Wanfang Data Co. Ltd. All Rights Reserved. |
| Copyright_xml | – notice: Copyright © Wanfang Data Co. Ltd. All Rights Reserved. |
| DBID | 2RA 92L CQIGP W95 ~WA 2B. 4A8 92I 93N PSX TCJ |
| DOI | 10.3969/j.issn.1002-6819.2014.22.014 |
| DatabaseName | 维普_期刊 中文科技期刊数据库-CALIS站点 维普中文期刊数据库 中文科技期刊数据库-农业科学 中文科技期刊数据库- 镜像站点 Wanfang Data Journals - Hong Kong WANFANG Data Centre Wanfang Data Journals 万方数据期刊 - 香港版 China Online Journals (COJ) China Online Journals (COJ) |
| DatabaseTitleList | |
| DeliveryMethod | fulltext_linktorsrc |
| Discipline | Agriculture |
| DocumentTitleAlternate | Experiment on long term seepage corrosion stability of plastic concrete |
| DocumentTitle_FL | Experiment on long term seepage corrosion stability of plastic concrete |
| EndPage | 119 |
| ExternalDocumentID | nygcxb201422014 663374742 |
| GrantInformation_xml | – fundername: 新疆维吾尔自治区研究生科研创新项目资助; 国家自然科学基金资助; 国家高等学校博士点专项科研基金资助; 新疆水利水电工程重点学科基金资助 funderid: (XJGRI2014072); (50969010); (20106504110005); (XJzdxk-2010-02-12) |
| GroupedDBID | -04 2B. 2B~ 2RA 5XA 5XE 92G 92I 92L ABDBF ABJNI ACGFO ACGFS AEGXH AIAGR ALMA_UNASSIGNED_HOLDINGS CCEZO CHDYS CQIGP CW9 EOJEC FIJ IPNFZ OBODZ RIG TCJ TGD TUS U1G U5N W95 ~WA 4A8 93N ACUHS PSX |
| ID | FETCH-LOGICAL-c594-e56b3ba097253238c52f5d256f9f8d5ff12c5efa9d256c9b305a85c8442a3e83 |
| ISSN | 1002-6819 |
| IngestDate | Thu May 29 04:04:18 EDT 2025 Wed Feb 14 10:30:46 EST 2024 |
| IsPeerReviewed | false |
| IsScholarly | true |
| Issue | 22 |
| Keywords | concretes corrosion 质量损失 plastics 渗流 溶蚀 强度损失 durability seepage strength loss 耐久性 mass loss 塑性 混凝土 |
| Language | Chinese |
| LinkModel | OpenURL |
| MergedId | FETCHMERGED-LOGICAL-c594-e56b3ba097253238c52f5d256f9f8d5ff12c5efa9d256c9b305a85c8442a3e83 |
| Notes | Wu Fufei, Shi Kebin, Dong Shuangkuai, Ci Jun, NuerkailiYiziteluopu （1. College of Civil and Hydraulic Engineering, Xinjiang Agricultural University, Urumqi 830052, China; 2. College of Pratacultural and Environmental Sciences, Xinjiang Agricultural University, Urumqi 830052, China） 11-2047/S concretes;plastics;seepage;corrosion;mass loss;strength loss;durability In order to evaluate long-term seepage stability and service life of plastic concrete that are made of bentonite, clay, cement, soil aggregate, water, superplasticizer, etc., we studied incomplete or contain holes of plastic concrete’s long-term seepage stability and service life. Specimens of plastic concrete were molded after many times of tests, and their compressive strength of 28 days was 1.25 MPa, and meet requirements impermeability grade was S1 which was test code for hydraulic concrete because water pressure measured was 0.2 MPa by step by step method. The preparation of plastic concrete permeability test required to a round-shaped specimen （top |
| PageCount | 8 |
| ParticipantIDs | wanfang_journals_nygcxb201422014 chongqing_primary_663374742 |
| PublicationCentury | 2000 |
| PublicationDate | 2014 |
| PublicationDateYYYYMMDD | 2014-01-01 |
| PublicationDate_xml | – year: 2014 text: 2014 |
| PublicationDecade | 2010 |
| PublicationTitle | 农业工程学报 |
| PublicationTitleAlternate | Transactions of the Chinese Society of Agricultural Engineering |
| PublicationTitle_FL | Transactions of the Chinese Society of Agricultural Engineering |
| PublicationYear | 2014 |
| Publisher | 新疆农业大学水利与土木工程学院,乌鲁木齐,830052%新疆农业大学草业与环境科学学院,乌鲁木齐,830052 |
| Publisher_xml | – name: 新疆农业大学水利与土木工程学院,乌鲁木齐,830052%新疆农业大学草业与环境科学学院,乌鲁木齐,830052 |
| SSID | ssib051370041 ssib017478172 ssj0041925 ssib001101065 ssib023167668 |
| Score | 2.031417 |
| Snippet | 为了评定塑性混凝土的长期渗流稳定性和使用年限，结合当地原材料的情况，采用膨润土、黏土、水泥、骨料、水和减水剂等来制备塑性混凝土，试验测定了完整或含孔洞塑性混凝土的长期渗流稳定性和使用年限。经过多次试配试验，选定配合比并制作试件，该试件在标准养护28 d后，其抗压强度为1.25... TU528.01; 为了评定塑性混凝土的长期渗流稳定性和使用年限，结合当地原材料的情况，采用膨润土、黏土、水泥、骨料、水和减水剂等来制备塑性混凝土，试验测定了完整或含孔洞塑性混凝土的长期渗流稳定性和使用年限。经过多次试配试验，选定配合比并制作试件，该试件在标准养护28 d后，其抗压强度为1.25... |
| SourceID | wanfang chongqing |
| SourceType | Aggregation Database Publisher |
| StartPage | 112 |
| SubjectTerms | 塑性 强度损失 混凝土 渗流 溶蚀 耐久性 质量损失 |
| Title | 塑性混凝土的长期渗流溶蚀稳定性试验 |
| URI | http://lib.cqvip.com/qk/90712X/201422/663374742.html https://d.wanfangdata.com.cn/periodical/nygcxb201422014 |
| Volume | 30 |
| hasFullText | 1 |
| inHoldings | 1 |
| isFullTextHit | |
| isPrint | |
| link | http://utb.summon.serialssolutions.com/2.0.0/link/0/eLvHCXMwpV3Nb9MwFLdGJyE4ID7FGKAd5mNL44_EPjptomkHLgxptypJk-7UsbFJsNOQkLhw4TAhTUMTJxAHOCAY4sJf0277L3jPcduApgFDqtzEfv695_cSP9t6dgiZhx6vSDm8aTwQSV0EiaynTDfrWTctGC-aXVbYKN_7_sJDsbgsl6dqi5Wopc2NtJFtnbiv5CxWhTywK-6S_QfLjkEhA67BvpCChSH9KxvTSFLjUe3RyMeQBRPgRRjgD4pgnq_beKFbVMc0gltDlaCRplrSMEZiVwS1FNVldahoAUNDQ59GytZqYnWjaMgt0wgzJ0wVNTFiArIB4lZ1yGslsYwiYbkYzAEJjXSYKrSYbWp8i2mgaPQgWPGbNBSWFgpjy4RTHU1IADeiyjZVSQsH_PyRHJZEoZaMFR4gVMvKEFMTTkh8W1mN5A2rCyLeZCnUgYdWI8jFP7mFRljVVBoWlu2wTIx2xCqqWMiCGHWqgsB4oAAG74ZF0LYxmobMmc0hQE4bNcdaCr8VAPTyrJIr1K3SFZqx5AGmYHskBgG4FTiwT-S4-v9KXvGb6Fh95bxf2WWU-82dY_RcsHzu7vRJ7ptrX1v3jZiNMSYGYIoGY42RsX89IL3_tJc9SZGGYXKOTLMg8GSNTJuwHcaTyYGH6x9j78XwDAh_MtmWHsdPPYwDxDA8QtpYCSfGeTLvZLx3moR4SMvKar-3BkNPuxOwXyT9XmXQunSZXHKzzTlTdh1XyNTWylVy0fTW3Yk7-TXCB29fDbffDQ8OBi_eDPb2D3efH-_8GO7tD7-9Hn55Nvz-9Wh3-_D958HHXSA7-rRz_OHldfIgjpZaC3X3JZV6JrWo59JPeZrgSV2Swxg9k9ADd2GyU-hCdWVReCyTeZFozMs09N0yUTJTQrCE54rfILX-aj-_SeayLoyHEi15V_oigW4-F02mmVCpB1m8mCGz48Z3HpXn5XRgUgOeIBBshsw5dXRcL_q485v1bv2ZZJZcwL9yHfQ2qW2sb-Z3YGawkd51Jv8JKiq-Iw |
| linkProvider | EBSCOhost |
| openUrl | ctx_ver=Z39.88-2004&ctx_enc=info%3Aofi%2Fenc%3AUTF-8&rfr_id=info%3Asid%2Fsummon.serialssolutions.com&rft_val_fmt=info%3Aofi%2Ffmt%3Akev%3Amtx%3Ajournal&rft.genre=article&rft.atitle=%E5%A1%91%E6%80%A7%E6%B7%B7%E5%87%9D%E5%9C%9F%E7%9A%84%E9%95%BF%E6%9C%9F%E6%B8%97%E6%B5%81%E6%BA%B6%E8%9A%80%E7%A8%B3%E5%AE%9A%E6%80%A7%E8%AF%95%E9%AA%8C&rft.jtitle=%E5%86%9C%E4%B8%9A%E5%B7%A5%E7%A8%8B%E5%AD%A6%E6%8A%A5&rft.au=%E5%90%B4%E7%A6%8F%E9%A3%9E&rft.au=%E4%BE%8D%E5%85%8B%E6%96%8C&rft.au=%E8%91%A3%E5%8F%8C%E5%BF%AB&rft.au=%E6%85%88%E5%86%9B&rft.date=2014&rft.pub=%E6%96%B0%E7%96%86%E5%86%9C%E4%B8%9A%E5%A4%A7%E5%AD%A6%E6%B0%B4%E5%88%A9%E4%B8%8E%E5%9C%9F%E6%9C%A8%E5%B7%A5%E7%A8%8B%E5%AD%A6%E9%99%A2%2C%E4%B9%8C%E9%B2%81%E6%9C%A8%E9%BD%90%2C830052%25%E6%96%B0%E7%96%86%E5%86%9C%E4%B8%9A%E5%A4%A7%E5%AD%A6%E8%8D%89%E4%B8%9A%E4%B8%8E%E7%8E%AF%E5%A2%83%E7%A7%91%E5%AD%A6%E5%AD%A6%E9%99%A2%2C%E4%B9%8C%E9%B2%81%E6%9C%A8%E9%BD%90%2C830052&rft.issn=1002-6819&rft.issue=22&rft.spage=112&rft.epage=119&rft_id=info:doi/10.3969%2Fj.issn.1002-6819.2014.22.014&rft.externalDocID=nygcxb201422014 |
| thumbnail_s | http://utb.summon.serialssolutions.com/2.0.0/image/custom?url=http%3A%2F%2Fimage.cqvip.com%2Fvip1000%2Fqk%2F90712X%2F90712X.jpg http://utb.summon.serialssolutions.com/2.0.0/image/custom?url=http%3A%2F%2Fwww.wanfangdata.com.cn%2Fimages%2FPeriodicalImages%2Fnygcxb%2Fnygcxb.jpg |